mac11irl

Yup. Small gaps in the underside of the door to let water back out.
and yeah, the plastic sheeting behind the door card is the membrane. The water in your pic is suspiciously close to the door speaker, so if that fiddled with or changed at some point odds are it wasnt 100% sealed before the door was put back together.

Pass - roadworthy for another 12months! Not even an advisory..

So, @stevestruck - well done, you got closest

And finally - following dealer warranty works - boot seal dodgy.
the furby was returned and much drier on the inside Lexi is parked outside... in the ****ing rain.
Good test to see if it was the only place, but i trust the guys in the dealer here

Im going to give you the win OCD
Have to get under the car this evening, when the wife gets home to confirm,
but im pretty sure i know your right.
Ffrom a quick look theres a heat shield above the exhaust, behind the wishbones,
Just at the start of the floor pan.
reckon its that one resonating at particularly low engine engine vibration

So i just went and swapped the fuse which was fine, with no lighter function,
then was blown yesterday... for a new 15amp, and it works...
 
WTF.... anyways, im not complaining, can charge fones and headlights on the move again :clap: